fireplace XTRORDINAIR 44-Elite Owner's Manual
Summary
The Fireplace Xtrordinair is a premium wood-burning home heater designed to provide both warmth and aesthetic appeal. This comprehensive owner's manual serves as your complete guide, providing critical information for new owners. It covers everything from safe installation requirements and proper operation techniques to crucial detailed maintenance procedures, including yearly cleanings and combustible warnings. By consulting this guide, you can ensure the efficient, safe, and maximum enjoyment of your fireplace while adhering to all necessary safety protocols.
Page 1 Text Content
44-Elite Owner's Manual SAFETY NOTICE: If this appliance is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and installation inspection requirements in your area.
Listed
© Copyright 2007, T.I.
$10.00 93508094 Tested to: U.L. 127 and
4800 Harbour Pointe Blvd SW portions of U.L. 1482 & 907 Mukilteo, WA 98275
Page Summary Contents For fireplace XTRORDINAIR 44-Elite Owner's Manual
Page 1
44-Elite Owner's Manual SAFETY NOTICE: If this appliance is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officia...
Page 3
Introduction Introduction We welcome you as a new owner of a Fireplace Xtrordinair wood fireplace. In purchasing a Fireplace Xtrordinair you have joined the growing ranks of concerned individuals whos...
Page 4
Safety Precautions This fireplace must be Contact your local installed by a qualified building officials to obtain installer. Installation a permit and information instructions are shipped on installa...
Page 5
Safety Precautions Do not repair, alter, or Allow the fireplace to cool replace any part of the before carrying out any fireplace and chimney maintenance or cleaning. unless instructions are give in t...
Page 6
Table of Contents Introduction Maintenance Introduction................................................1 Daily Maintenance (while fireplace is in use) ......14 Important Information .....................
Page 7
Specifications Features: Maximum Log Length of 32" Large firebox capacity - 4.3 cu. ft. Long burn time - from 10 to 12 Hours Large glass doors for maximum visibility Firebrick lining for firebox ...
Page 8
Operation Safety Notice: If this appliance is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restr...
Page 9
Operation Opening the Doors Follow the directions below to open and close the doors. AAAAAAA AAAAAAA AAAAAAA AA AAA Pull the By-Pass AA Control all the way Twist the left out (use gloves or handle cou...
Page 10
Operation Location of Controls AA AAAAAAA By-Pass AAAAAAWhen hot, use Control gloves to adjust AA AAAAAAA AAA AAAAAA the controls. AAAAAAAA AAA AAAAAA AAAAAA Air AAAAAAAA AA AAAAAA Control AAAAAAAA AA...
Page 11
Operation Maintaining Catalytic Burn-Off This fireplace uses a catalytic combustor to increase heat transfer to the room and reduce emissions. The catalytic combustor takes dirty smoke and turns it in...
Page 12
Operation Adjusting the Burn Rate Use the air control slider to control the burn rate of the fireplace. See the illustration below for details. Use the air control to change the burn rate. AAAAAAAAAA ...
Page 13
Operation Re-Loading the Fireplace Follow the directions below to minimize smoke spillage while re-loading the fireplace. Pull the by-pass out all the way (use a glove or tool). Move the air control t...
Page 14
Operation Selecting Wood Dry Wood is Key Wet Dry Wood Wood Leads Leads To To Dry wood burns hot, emits less smoke and creates less creosote. Less More Heat Heat Leads Leads To To More Smoke Less Smoke...
Page 15
Operation Troubleshooting Problem Possible Cause Smoke Enters Room Cold Air Blockage - burn a piece of newspaper to During Start-Up establish a draft. By-pass is Closed - Open the by-pass by pulling t...
Page 16
Maintenance Daily Maintenance (while fireplace is in use) Check Ash, Remove if Necessary Ash can build up inside the firebox without affecting performance. Generally, remove ash once it has built up o...
Page 17
Maintenance Twice Yearly Maintenance Check Firebrick, Baffle With the fireplace completely cool, remove ash from the firebox (see the instructions on the previous page) and check the firebrick and baf...
Page 18
Maintenance Check Door Seal, Adjust if Necessary The door latch and door gasket work in conjunction to seal the firebox. If the doors do not seal, air will leak into the firebox and cause the fire to ...
Page 19
Maintenance Check Chimney for Creosote Build-Up Remove the chimney cap and carefully inspect for creosote build-up over the entire length of chimney. If creosote build-up is over 1/4", the chimne...
Page 20
Safety Label Fireplace Xtrordinair SERIAL NO. LISTED FACTORY BUILT FIREPLACE MODEL NO. 44 ELITE TESTED TO: UL-127 REPORT NO. 028-F-61-4 MANUFACTURE DATE: WARNING: • Operate with feed doors closed. Ope...
Page 21
Limited 7 Year Warranty To register your TRAVIS INDUSTRIES, INC. 7 Year Warranty, complete the enclosed warranty card and mail it within ten (10) days of the appliance purchase date to: TRAVIS INDUSTR...
Page 22
Optional Equipment Temperature Meter The temperature meter displays the temperature of the combustor, allowing the operator to monitor combustor light-off. To obtain a suitable temperature meter, cont...
Page 23
Optional Equipment Travis Industries
Page 24
Index Acid Wash...................................................6 Important Information .............................1 Adjusting the Burn Rate...............................10 Index ...................
Manual Details
| Brand | Elite |
|---|---|
| Pages | 24 |
| File Size | 480.21 KB |
| Published | June 03, 2026 |
58 views
Enter the captcha to get the download link:
Frequently Asked Questions
Who must install this fireplace for it to be safe?
Installation must be performed by a qualified building official or professional.
What fuel types are allowed in the Fireplace Xtrordinair?
It is designed only to burn solid wood fuel (cord wood). Treated wood, coal, or wax logs are prohibited.
How should I dispose of fireplace ashes safely?
Ashes must be contained in a metal container with a tight-fitting lid and kept at least 36 inches away from the fireplace until they fully cool.
How often does the chimney require professional inspection?
The chimney must be inspected twice yearly for creosote build-up or damage by a qualified service person.